Journal of Advanced Materials in Engineering

Journal of Advanced Materials in Engineering

Investigating the Corrosion Resistance and Antimicrobial Behavior of Polyethylene-Silver Zeolite Composite Coatings on 304 Stainless Steel Substrate

Document Type : Original Article

Authors
S. Shirani
R. Emadi
A. Eslami
Department of Materials Engineering, Isfahan University of Technology, Isfahan 84156-83111, Iran
10.47176/jame.43.3.1046
Abstract
Today, due to the presence of various microbial species and the reduction in healthcare costs, the use of antimicrobial materials has become indispensable for human society. Silver is the most widely used and effective antimicrobial agent, capable of penetrating bacterial structures and disrupting their biological systems. Among all methods of employing silver ions, the selection of zeolites, such as natural clinoptilolite with a crystalline aluminosilicate structure, hydrated, finely porous, and highly water-absorbent due to the ion release mechanism, has garnered significant attention. Heavy polyethylene is one of the corrosion-resistant polymers produced in Iran, offering insulation, quality, and cost-effectiveness. Due to its non-toxic nature and minimal environmental concerns, it has gained considerable attention. This research introduced silver ions into the porous zeolite network through an ion exchange mechanism. Subsequently, composite polyethylene coatings containing 0%, 10%, and 20% by weight of silver zeolite were applied on the 304 AISI stainless steel substrate using dip coating method. The coatings were then characterized through X-ray diffraction and scanning electron microscopy . The results indicated that with an increase in silver zeolite content within the polyethylene matrix, the coatings became more homogeneous, thicker, and corrosion-resistant. After applying the coatings, their corrosion behavior in a 3.5% wt.% NaCl environment was studied during 10, 24, 40, 70, and 100 days using electrochemical impedance spectroscopy. According to the results of electrochemical impedance spectroscopy, adding silver zeolite to polyethylene coatings up to 10 wt.% reduced corrosion resistance, while adding 20 wt.% increased corrosion resistance in the scratch-resistant coatings. Finally, by exposing the samples to a bacterial environment containing gram-negative (Escherichia coli) and gram-positive (Staphylococcus aureus) bacteria, their antimicrobial properties were evaluated for potential antibacterial applications. The results from the halo and colony count tests suggested an improvement in antimicrobial efficacy against Staphylococcus aureus compared to Escherichia coli with increasing content of silver zeolite.
Keywords
Coating
Composite
Polyethylene
Zeolite
Silver ion
Stainless steel
Electrochemical impedance
Antimicrobial
Subjects
  1. Morones JR, Elechiguerra JL, Camacho A, Holt K, Kouri JB, Ramírez JT, et al. The bactericidal effect of silver nanoparticles. Nanotechnology. 2005; 16(10): 2346. https://doi.org/10.1088/0957-4484/16/10/059
  2. Akgül M, Karabakan A, Acar O, Yürüm Y. Removal of silver (I) from aqueous solutions with clinoptilolite. Microporous Mesoporous Mater. 2006; 94(1–3):99–104. https://doi.org/10.1016/j.micromeso.2006.02.023
  3. Naghizadeh Baghi S. Fabrication of antibacterial silver-containing nanocomposite for use in refrigerator body materials. Ministry of Science, Research, and Technology - Faculty of Materials Engineering, Tarbiat Modares University; 2009. (In Persian)
  4. Kazemian H. Introduction to Zeolites: The Mysterious Minerals. Behesht Publications; 2004. (In Persian)
  5. Michalik A. Conductive Polymers for Corrosion Protection: Acritical Investigation. Ph. D Thesis, Ruhr-Bochum-University. 2009.
  6. Jia Z, Liu Y, Wang Y, Gong Y, Jin P, Suo X, et al. Surface & Coatings Technology Flame spray fabrication of polyethylene-Cu composite coatings with enwrapped structures : A new route for constructing antifouling layers. Surf Coat Technol. 2016;309:872-879. https://doi.org/10.1016/j.surfcoat. 2016.10.071
  7. Ghiyour H. High-density polyethylene (HDPE) coating produced by electrostatic spraying on plain carbon steel. Faculty of Materials Engineering, Isfahan University of Technology; 1997. (In Persian)
  8. Iqbal N, iqbal S, iqbal T, bakhsheshi-rad HR, alsakkaf A, kamil A, et al. Zinc-doped hydroxyapatite zeolite/polycaprolactone composites coating on magnesium substrate for enhancing in-vitro corrosion and antibacterial performance. Trans Nonferrous Met Soc China. 2020;30(1):123–33. https://doi.org/10.1016/S1003-6326(19)65185-X
  9. Salim MM, Ahmad N, Nik N. Characterization and antibacterial activity of silver exchanged regenerated NaY zeolite from surfactant-modi fi ed NaY zeolite. Mater Sci Eng C. 2016;59:70–7. https://doi.org/10. 1016/j.msec.2015.09.099
  10. Shekarani R. Application of natural zeolite activated with hydrochloric acid in the synthesis of Cu/Clinoptilolite-CeO2 nanocatalyst for oxidation of volatile organic compounds in polluted air at low temperatures. 2013; 5:1-10. (In Persian)
  11. Cerrillo JL, Palomares AE, and Rey F. Silver exchanged zeolites as bactericidal additives in polymeric materials. pre proof. 2018;305:110367. https://doi.org/10.1016/j.micromeso.2020.110367
  12. Xu X, Ding H, Wang BK. Preparation and Performance of Ag+-Zn2+-Zeolite Antimicrobial and Antibacterial Plastic. Adv Mater Res. 2010;96:151–4. https://doi.org/10.4028/www.scientific.net/AMR.96.151
  13. Rivera-Garza M, Olguın MT, Garcıa-Sosa I, Alcántara D, Rodrıguez-Fuentes G. Silver supported on natural Mexican zeolite as an antibacterial material. Microporous mesoporous Mater. 2000;39(3): 431–44. https://doi.org/10.1016/S1387-1811(00)00217-1
  14. deAraújo L, Pergher S, Anaya K. Synthesis of antimicrobial films based on low-density polyethylene (LDPE) and zeolite a containing silver. Coatings. 2019;9(12). https://doi.org/10.3390/coatings9120786
  15. Abdi A. Investigation of the antibacterial properties of silver nanoparticles and polyethylene-silver nanocomposites. 2015; 6:159-168. (In Persian)
  16. Chellappa M, Vijayalakshmi U. Electrophoretic deposition of silica and its composite coatings on Ti-6Al-4V, and its in vitro corrosion behaviour for biomedical applications. Mater Sci Eng C. 2017;71: 879–90. https://doi.org/10.1016/j.msec.2016.10.075
  17. Sondi I, Salopek-Sondi B. Silver nanoparticles as antimicrobial agent: a case study on E. coli as a model for Gram-negative bacteria. J Colloid Interface 2004;275(1):177–82. https://doi.org/10.1016/j.jcis. 2004.02.012
  18. Puetz J, Aegerter MA. Dip Coating Technique. In: Sol-Gel Technologies for Glass Producers and Users. Boston, MA: Springer US. 2004:37–48.
  19. Matin E, Attar MM, Ramezanzadeh B. Investigation of corrosion protection properties of an epoxy nanocomposite loaded with polysiloxane surface modified nanosilica particles on the steel substrate. Prog Org Coatings. 2015;78:395–403. https://doi.org/ 10.1016/j.porgcoat.2014.07.004
  20. Singh SK, Tambe SP, Gunasekaran G, Raja VS, Kumar D. Electrochemical impedance study of thermally sprayable polyethylene coatings. Corros Sci. 2009;51(3):595–601. https://doi.org/10.1016/j. corsci.2008.11.025

 

 

 

Journal of Advanced Materials in Engineering
Volume 43, Issue 3
2024
Pages 85-97

تحت نظارت وف ایرانی